ATV Service
ATV & UTV & Motorcycle Service FULL SERVICE & Tune up!
- CHECK COMPRESSION
- CLEAN & INSPECT CARBURETOR SET PILOT AIR OR FUEL SCREW
- INSPECT FUEL SYSTEM HOSES, VENTS AND SHUT OFF FOR LEAKS OR KINKS
- CHANGE FUEL FILTER & ENGINE CRANK CASE BREATHER FILTER
- CLEAN OR REPLACE AIR FILTER(S)
- CLEAN & INSPECT AIRBOX, CHECK INTAKE DUCTS & FLANGES, DRAIN AIR BOX SEDIMENT TUBE
- INSTALL NEW SPARK PLUGS
- INSPECT & ADJUST THROTTLE AND CHOKE CABLES.CHECK ETC SWITCH
- CHANGE ENGINE OIL & FILTER (2 STROKE CHANGE INLINE OIL FILTER)
- TEST BATTERY, CHECK FLUID LEVEL & HOLDDOWN STRAP, CLEAN TERMINALS
- CHECK ALL LIGHTS FOR PROPER OPERATION
- CHECK BRAKES, FLUID LEVEL, PADS, DISCS, & PARK BRAKE, BLEED SYSTEM, ADJUST AUXILLARY BRAKE
- INSPECT COOLING SYSTEM FITTINGS, HOSES & CLAMPS, COOLANT LEVEL, SPECIFIC GRAVITY, PRESSURE TEST IF LEAK SUSPECTED
- CHANGE TRANSMISSION FLUID
- CHANGE FRONT & REAR GEARCASE FLUID
- CHECK FRONT WHEEL BEARINGS, CHANGE AWD HUB FLUID
- LUBE ALL GREASE FITTINGS
- INSPECT ENGINE MOUNTS
- SET STEERING ALIGNMENT
- CHECK TIE ROD ENDS, BALL JOINTS, A- ARM BUSHINGS, SWING ARM BUSHINGS & SHOCKS
- CHECK AIR PRESSURE IN TIRES
- DRAIN RECOIL HOUSING
- INSPECT OIL PUMP CABLE, HOSES, & ADJUSTMENT (2 STROKE)
- CHECK REAR AXLE BEARINGS AND HUBS
- CHECK ALL U-JOINTS & CV BOOTS
- INSPECT EXHAUST SYSTEM FOR LEAKS, CRACKS, OR MISSING SPRINGS
- INSPECT DRIVE CHAIN(S) & SPROCKETS, ADJUST & LUBE CHAIN(S)
- CHECK WHEEL NUT TORQUE
- CHECK & TIGHTEN FRAME & SUSPENSION NUTS, BOLTS & FASTENER, CHECK ALL COTTER PINS
- CHECK & TIGHTEN SPOKES (MOTORCYCLES)
- ADJUST BRAKE & CLUTCH CABLES
- CHECK FORK SEALS FOR LEAKS (MOTORCYCLES)
- TEST RIDE: CHECK FOR SMOOTH OPERATION OF ENGINE, DRIVETRAIN & BRAKES, IDLE SPEED SET CORRECTLY AFTER WARM
- REVERSE OVERRIDE SAFETY SYSTEM WORKS CORRECTLY (POLARIS ATV)
ATV & UTV & Motorcycle BASIC SERVICE & Tune up!
- INSPECT FUEL SYSTEM HOSES, VENTS AND SHUT OFF FOR LEAKS OR KINKS
- CHANGE FUEL FILTER
- CLEAN OR REPLACE AIR FILTER(S)
- CLEAN & INSPECT AIRBOX, CHECK INTAKE DUCTS & FLANGES, DRAIN AIR BOX SEDIMENT TUBE
- INSTALL NEW SPARK PLUGS
- INSPECT & ADJUST THROTTLE AND CHOKE CABLES.CHECK ETC SWITCH
- CHANGE ENGINE OIL & FILTER (2 STROKE CHANGE INLINE OIL FILTER)
- CHECK ALL LIGHTS FOR PROPER OPERATION
- CHECK BRAKES, FLUID LEVEL, PADS, DISCS, & PARK BRAKE, BLEED SYSTEM, ADJUST AUXILLARY BRAKE
- INSPECT COOLING SYSTEM FITTINGS, HOSES & CLAMPS, COOLANT LEVEL, SPECIFIC GRAVITY, PRESSURE TEST IF LEAK SUSPECTED
- CHECK TRANSMISSION FLUID
- CHECK FRONT & REAR GEARCASE FLUID
- CHECK FRONT WHEEL BEARINGS, CHECK 4X4 HUB FLUID
- LUBE ALL GREASE FITTINGS
- INSPECT ENGINE MOUNTS
- CHECK AIR PRESSURE IN TIRES
- CHECK REAR AXLE BEARINGS AND HUBS
- CHECK ALL U-JOINTS & CV BOOTS
- INSPECT EXHAUST SYSTEM FOR LEAKS, CRACKS, OR MISSING SPRINGS
- INSPECT DRIVE CHAIN(S) & SPROCKETS, ADJUST & LUBE CHAIN(S)
- ADJUST BRAKE & CLUTCH CABLES
PMS WILL (ADD Lubricants/Fluids or make adjustments if NEEDED)
